I would suspect that maybe there are also some oil pressure issues leading to the pump being replaced. I have done head-gasket replacements on engines of this mileage with some success. Yes, Vanagon connecting rods can and do fail along with the cam shaft and cam bearings. But I would not just say that at 150K a rebuild is in order unless there are some other considerations. Were you able to determine of the combustion leak was due to the cracked head? If due to loose heads you may want to replace the studs. These are almost a torque to yield and leakage at the top of the cylinders means the studs no longer maintained enough tension to keep the heads down under pressure. Dennis
-----Original Message----- From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of Tom Lambas Sent: Monday, September 06, 2010 6:35 PM To: vanagon@GERRY.VANAGON.COM Subject: Should I rebuild the bottom end? Questions & photos. My '86 Vanagon has 178k miles on the odometer. The PO had headgaskets, oil pump, one head (used), a couple of lifters and a rocker arm assembley replaced. Test drive seemed fine, and I bought it. Well , it didn't take long before I had overheating issues that I ultimately found to be exhaust gasses blowing into the coolant. Pulled the heads, one was junk with a crack between the valves. I had the good head and another head rebuilt and pressure tested. I've pulled the barrels and pistons, and I am wondering whether to rebuild the bottom end, or not. Side play on the connecting rods seems normal. I can't feel any play when I push/pull toward or away from the crankshaft. I'm also wondering if it's normal for the core to show what looks like fine cracks on the solid area to the left of the connecting rod (see photos). Wrist pin wear looks minimal and the pistons look pretty good, but I'll probably replace the pistons. Thanks for any advice, Tom |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.