pretty good right up on ign switch removal (with pics) here on ben's place http://www.benplace.com/dash.htm
fan switch can be replaced with dash in. Need to take off heater control panel... and be careful pulling the control levers. They can be stiff, try pliers on shaft, not knob, and control the pull so that the don't come out suddenly and break the panel. The panel can be held in tight too, ease it off carefully, 2 bosses in panel go into holes in dash. Tight fit and brittle plastic means be gentle :) I took some pics of how the lighter goes together http://shufti.wordpress.com/2010/03/14/vanagon-lighter-socket/ From that you will see that it can't be tightened up much. Its a poor deign IMHO. alistair
On 19-Feb-11, at 9:25 AM, Michael Sullivan wrote: > Just wanted some advice before I start on these chores. > Symptom-Slow cranking/no cranking new starter and battery drain and > ignition > switch going out. > > I am going to check the grounds from alt to chassis and from tranny to > chassis. I wanted to run new battery cable to alt, but Bently says > you have > to remove the gas tank to do this properly. Is this true? > > Ignition switch-pg 94.2....Is this the only way to go about this? > Fig 2 > needs a special tool. (I got two of these switchesso I will have a > backup). > > Fan switch in dash. Speed 3 does not work unless I lightly touch the > switch. I got a new one and need to know if this can be checked/ > replaced > without removing the dash? > > Lastly, I got a new cigarette lighter socket(with green > illumination). Mine > is a little loose. Can this be done without removing the dash? > > Well, that's it. It's raining so I cannot work on the grounds > today, but > thought I would take the main battery out and have it checked while > I work > on the switches today inside the van. I appreciate any advice. > Thanks. > > Michael in San Antonio > 91GL Weekender AT 2.1L 'Gringo' |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.