Hello David:
I fired up the 1968 model Heathkit VTVM and checked it out with various batteries. Voltage from O2-sensor is zero, even after engine warms up. Time to order another O2-sensor and see if it will last longer than this one did. Thank you for your help. John
________________________________ From: David Beierl <dbeierl@attglobal.net> To: John Lauterbach <jhlauterbach@BELLSOUTH.NET> Cc: vanagon@GERRY.VANAGON.COM Sent: Tue, August 23, 2011 10:09:14 AM Subject: Re: O2-sensor voltage problems '84 1.9L -- Help needed At 09:31 AM 8/23/2011, John Lauterbach wrote: > Here are the details. O2-sensor not connected. Voltage from O2-cable > coming from engine is +0.46 volts. Again, O2-sensor is not connected. > I have tried with two different ECUs and get same result. This is normal. The ECU applies a bias voltage to the line so it can tell when the sensor heats up and comes on line (and swamps the bias signal).
> With engine off, resistance between O2-cable coming from engine and > ground is 140K ohms. I have a spare FI cable assembly and get same > resistance from that cable when a ECU is connected. That sounds like a not-unreasonable value.
> If I connect O2-sensor as intended, engine runs rich and stalls. Using a digital meter,* describe the behavior of the O2 sensor while disconnected from the ECU and engine running, blipping throttle, fast idle and such. I'm expecting that you're going to see output of zero or close to it under all running conditions. Connect the sensor (ok to do while engine running) - I expect you'll still see zero or very low output. This would indicate either bad sensor or oxygen getting into the exhaust through misfiring cylinder or exhaust leak. *Oscilloscope would be great, analog meter would also be great but would need sensitivity of at least 40-50 kohms per volt and set on maybe three-volt scale. An indicator based on an LM3914, such as the one that Ken Lewis sells would also be excellent. Since you probably don't have any of these, a regular digital meter on two-volt scale is usable though unwieldy. If it has a fast-acting bar-graph as part of the display that would help. Yours, David |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.