Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (September 2011, week 2)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Sat, 10 Sep 2011 19:34:54 -0700
Reply-To:     Old Volks Home <oldvolkshome@GMAIL.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Old Volks Home <oldvolkshome@GMAIL.COM>
Subject:      Re: 1991 Westy,
              gas tank return hose size (and fuel line or injector line)?
Comments: To: Steve Williams <steve@williamsitconsulting.com>
In-Reply-To:  <4E6C1479.7080403@williamsitconsulting.com>
Content-Type: text/plain; charset=ISO-8859-1

What VW used is 7mm ID hose and use the higher pressure line - much better quality than the low pressure line anyway. -- Jim Thompson 84 GL 1.9 "Gloria" 84 Westfalia 2.1 "Ole Putt" 72 411 Station Wagon "Pug" 75 914 1.8 "Nancy" Full Timing Since March 1999 oldvolkshome@gmail.com http://www.oldvolkshome.com *********************************** On Sat, Sep 10, 2011 at 6:52 PM, Steve Williams <steve@williamsitconsulting.com> wrote: > Hi, > > I am in the middle of re-sealing my gas supply system.  I recently did > the gas tank reseal, complete with the bits of hoses to the expansion > tanks.  Unfortunately, I didn't have any hose to replace the gas > tank->fuel pump, and the gas return into the tank. > > Of course, now that I am going to do those two bits of hoses, I have a > full tank of gas :-( > > I got the right size for the gas tank->fuel pump and got it installed > with only minor spillage (outside). > > I slid the crawler over to the driver's side, crept under the propane > tank and cut a piece of the same (large) size of gas line. > Disconnecting the hose from the gas tank, I watched as it poured out of > a much smaller pipe than the outlet... the piece of hose in my hand (12 > mm?) was just too huge.  A bit stunned, I shoved the old piece of hose > back on, clamped it down and am letting the ample spillage (I was a bit > dumbstruck) evaporate. > > Does anyone know what size of hose the "return" on the gas tank of a > 1991 Westfalia/Vanagon is? > > Also, I made an assumption that this would be low pressure fuel line, > not the higher pressure injector hose.  Was that a correct assumption? > > Thanks, > Steve W.


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.