Date: Sun, 27 Nov 2011 09:34:47 -0800
Reply-To: HotelWestfalia <zolo@FOXINTERNET.NET>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: HotelWestfalia <zolo@FOXINTERNET.NET>
Subject: Re: fuel leak, '91 VW Vanagon GL Campmobile 2.1L
In-Reply-To: <BF5706EB-7827-4011-8DED-B3CF062F5DA6@shaw.ca>
Content-Type: text/plain; format=flowed; charset="iso-8859-1";
reply-type=original
If the overflow system has never been renewed, it is time to do it. It
takes a little work and some fuel lines and new grommets. It can be a pita
kind of job for an impatient patient.
The tank does not have to be fully taken out but dropped at the rear side.
Zoltan
----- Original Message -----
From: "Alistair Bell" <albell@SHAW.CA>
To: <vanagon@GERRY.VANAGON.COM>
Sent: Sunday, November 27, 2011 8:23 AM
Subject: Re: fuel leak, '91 VW Vanagon GL Campmobile 2.1L
could be the large grommet sealing the filler tube to the tank, the
connections on the filler tube itself (adjacent to the body, inthe wheel
well), the small hose coming off the filler tube or it could be one of the 3
(?) grommets in the top of the tank (those grommets which seal the tubes to
the expansion tanks).
You might be able to see a leak in the filler assembly, the grommets on the
top of the tank are harder to see when tank in van. You can reach in and
feel them with your hand. Chances are it is the harder to see grommets. If I
was you I'd plan on dropping the tank and replacing them.
alistair
On 2011-11-27, at 7:46 AM, Dave Mcneely wrote:
> Last time I filled the fuel tank on my camper, fuel ran out from the top
> of the
> tank somewhere. I was at at gas station/convenience store, and went into
> the
> store for something after filling up. When I came out, I noticed a small
> puddle
> under the van, and more fuel dripping down. I investigated and found that
> the
> fuel seemed to come from the top of the gas tank. I left the van sitting
> for a
> bit, and the drips decreased, stopped. I then started it up, drove it a
> few
> blocks, and there seemed to be no more leak. Therefore, with rechecking
> periodically, I risked driving home, some 60 miles. Seemingly no more
> leaks.
> Now, there it sits in the driveway, showing no evidence of leaking. One
> other
> point may matter. The automatic shutoff on the nozzle failed. The filler
> inlet
> did not overflow, because I was attentive. However, there was gasoline
> all the
> way to the top of the inlet tube.
>
> So, is the inlet tube bad? Will I only know where the leak came from by
> dropping the tank? I think that, though I think it must be the inlet tube
> or
> its connection to the tank.
>
> I have never noticed a gasoline smell after filling up, and I have never
> had a
> leak (overflow?) like this before to my knowledge. However, this leak was
> substantial.
>
> mcneely
|