Date: Wed, 4 Apr 2012 18:27:05 -0700
Reply-To: HotelWestfalia <zolo@FOXINTERNET.NET>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: HotelWestfalia <zolo@FOXINTERNET.NET>
Subject: Install extermal oil cooler? Re: Trans fluid in coolant system
In-Reply-To: <1995308394.462109.1333587629435.JavaMail.root@sz0063a.westchester.pa.mail.comcast.net>
Content-Type: text/plain; format=flowed; charset="UTF-8"; reply-type=original
I checked on TheSamba and found an affordable oil cooler, something that
other cars use, without using the cooling system to mess up the
transmission.
As I was looking at the oiriginal oil cooler, I did not see great usefulness
of it, knowing the cooling system is not very cool itself being 87 C.
What is the opinion of the List?
Zoltan
----- Original Message -----
From: "J Stewart" <fonman4277@COMCAST.NET>
To: <vanagon@GERRY.VANAGON.COM>
Sent: Wednesday, April 04, 2012 6:00 PM
Subject: Re: Trans fluid in coolant system
> Welllllllllll, wait a sec, design flaw? After all, these vehicles are all
> over 20 years old. A while back I was researching used SUVs and the Nissan
> Pathfinder is well known for the same problem, with A LOT less age and
> mileage. And Nissan will tell you take a hike as far as covering repairs,
> which average $3,500.00. Jeff Stewart ----- Original Message -----
>> I recommend you get an external cooler, if you can rescue you
>> automatic
>> transmission (by best doing 2 oil changes and driving the first for a
>> couple of days!
>> I had this problem before, and then I replaced the cooler with a used
>> one
>> which also lasted only a few month now my transmission is bad - I have
>> no
>> idea if it can be rebuild or if I should better replace it!
>> Anyhow this cooler is kind of a design flaw! Remove that failure
>> opportunity, its better to loose the transmission oil than to get
>> water
>> into the transmission!
>> On Wed, Apr 4, 2012 at 11:43 AM, HotelWestfalia
>> <zolo@foxinternet.net>wrote :
>> > Hi to all,
>> >
>> > This is a first to me. The transmission cooler has failed, thus
>> > releasing
>> > a lot of oil into the cooling system. Now I'm not sure how to rinse
>> > the
>> > whole system to get rid of the oil. If detergent to be used, what
>> > kind and
>> > how much to a gallon of water.
>> >
>> > Also I was real surprised how expensive a new cooler cost, between
>> > 530 and
>> > 300 dollars. I would think an external radiator type cooler would be
>> > cheaper and better for the purpose, as is used on other cars.
>> >
>> > Zoltan
>> >
>> --
>> Tobias Gogolin
>> Tel. Movistar (646) 124 32 82
>> Tel. Telcel (646) 160 58 99
>> skype: moontogo
>> messenger: usertogo@hotmail.com
>> First Bitcoin Account: 1LCupcVd8HhAGyVhd3xayPpnQHeis7rAiV
>> Blog: http://zeitgeistensenada.blogspot.com/
>> You develop Sustainable Ranch Technology at
>> http://tech.groups.yahoo.com/group/SURA-TECH
>> an Open Source Electric Motor/Alternator at
>> http://groups.yahoo.com/group/Performance_Axial_Flux
>> and an Open Source Motor Controller at
>> http://groups.yahoo.com/group/GoBox
>
| 
