I've had to work over the battery cables, ground cables and charging wires on my 85 .and other vans. a few points.. get a diesel vanagon battery with around 600 cold cranking amps at least. one limitation of the early vans ( pre 86 ) is that they have a small battery cable from battery to starter. I ran an extra cable..I have two parallel battery cables going to my starter in my 85 Vanagon. make sure the 'charging wire' from Alternator to starter is good ..as in bigger than normal .. make sure the trans ground strap is good. try to have a robust charnging voltage ..at least 14.0 volts ...14.5 is nice. See what it is at the alternator and the starting battery .. should be more than half a volt less at the starting battery. If you have an aux battery .....that battery and isolator device can cause 'issues' about starting ..maybe. Take that out of the picture until you get reliable starting well established. I prefer a manual battery switch for an aux battery charging myself. this usually does it...working over battery cables and charging wires. I also had to add a small toggle switch for my radio .. the one I have draws a small current all the time for memory .. it will make my 85 very hard to start in a week.. so I have it switch 'hard off' via a small toggle swithdc most when van is parked. basically though .. if you have a good hot battery, a quality new rebuilt starter.. and *fairly robust charging voltage* .. that usually does it.....working over the battery cables and charging wire/s. it's somewhat characteristic of all car brands .. as they add more and more.. the last year before a big upgrade is on the weak side... the fatter main battery cable and more robust starter to spin a 2.1 engine ..versus the smaller main battery cable and smaller starter in an 85 fits this. 85's are good though .. first year of the better sliding door..last year of the better round headlights. Any engine will fit of course ( I run a 2.1 wbxr on the early Digijet EFI and 1.9 cooling system ..and love it, for a waterboxer ) .. the only thing not really 'better' on 85's is the old style fuse box.
have fun ! scott www.turbovans.com
On 4/13/2012 1:44 PM, Ken Olsen wrote: > I'm pretty baffled. My 85' Westfalia waterboxer has been turning over > slowly since I bought it several years ago, but it has finally got to the > point of stranding me. It is behaving like a low battery, but I think I > have ruled that out. > > Symptoms: > Turns over very slowly, sometimes stopping (or catching?) > Runs fine when started. > Battery voltage looks good. Jumping doesn't help. > Voltage at starter matches battery. > Turns over slowly with: > - spark plugs removed. > - fresh battery jumpered directly to starter. > - WITH NEW STARTER INSTALLED! > > What am I missing? > > Thanks, > > Ken in Oregon. > |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.