Date:         Sat, 5 May 2012 12:49:09 -0400
Reply-To:     Harold Teer <teer.vanagon@GMAIL.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Harold Teer <teer.vanagon@GMAIL.COM>
Subject:      Re: Alternator belt burning up?
Comments: To: ralph meyermann <ralphmeyermann@gmail.com>
In-Reply-To:  <CAAj276yV4UXwvHDaOLS+-tuVi-B+wJ3DTYjvh_+69EGzVyC_0w@mail.gmail.com>
Content-Type: text/plain; charset=ISO-8859-1

Ralph,

I know nothing about the diesel engine in a Vanagon, so don't know if the
following is even close to applicable.   Several years ago I had someone
replace a leaking gasket on a fitting behind the pulley on the water pump
on my 2.1.  All worked fine it seemed but when I went to change all of the
belts several months later, the one for the alternator kept being thrown.
Low and behold, the person who had removed the pulley for the water pump
had put it on backwards.  Scott advised me to check that and sure enough
that was the problem and after I reversed the pulley, all was fine.  I have
no idea how the belt had stayed on during that time, but I can attest to
the fact that a new belt would not stay on with the pulley reversed.

Worth a look,

Harold





On Sat, May 5, 2012 at 12:21 PM, ralph meyermann
<ralphmeyermann@gmail.com>wrote:

> It spins very freely without belt on it,It will spin for 2-3+  seconds.
> Don't know if its caused by a heavy load when charging?? After start up I
> hit the throttle for a second to engage charging it bogs the motor a touch?
>
> Velma 82diesel 1.6 na westy
>
> On May 5, 2012 10:46 AM, "Tom Hargrave" <thargrav@hiwaay.net> wrote:
>
> More than likely there is enough free play in the front or rear bearing to
> cause the rotor to drag.
>
> Also, you might have a pulley alignment problem but if it's been running
> fine this is not likely.
>
>
> Thanks, Tom Hargrave
> www.stir-plate.com
> www.towercooler.com
> www.kegkits.com
> www.grow-sun.com
>
>
> -----Original Message-----
> From: Vanagon Mailing List [mailto:vanagon@GERRY.VANAGON.COM] On Behalf
> O...
>
> Sent: Saturday, May 05, 2012 10:29 AM
> To: vanagon@GERRY.VANAGON.COM
>
> Subject: Re: Alternator belt burning up?
>
> Bearing locking up under load?
>
> Velma 82diesel 1.6 na west...
>
> -----
> No virus found in this message.
> Checked by AVG - www.avg.com
> Version: 10.0.1382 / Virus Databa...
>



--
__________
Harold Teer
1991 Westy
Harrisonburg, VA