"One thing to keep in mind is that as the engine is running fuel is recirculating throught eh system, picking up heat from the engine and from the pumping process eventually raising the temperature of the fuel in the tank. As the temperature increases so does the vapor pressure making vapor lock that much easier to occur. If the fuel vaporizes at the suction inlet of the pump all bets are off." Ah. Dennis, that might be it. The periodicity of the shut-downs correlated with the heat and grade. The steeper and hotter, the more frequent, at one point giving a 15 second on / 5 second off duty cycle, and maybe a pump creating cavitation bubbles would do that. If that's what it is, then there's no solution except pull over to the side of the road -- if the mountain road in question has a shoulder -- and let things cool. While sitting in 100 degree F conditions and, as these things usually work out, in direct sunlight, too. (Grasps at straw) Maybe removing the pre-pump filter would cut down on the cavitation. -- Jack "Rocket j Squirrel" Elliott 1984 Westfalia, auto trans, Bend, Ore. On 08/19/2012 07:26 PM, Dennis Haynes wrote: > Almost all modern fuel injected vehicles have the filter on the pressure > side, (after), of the pump(s). Not only did VW make this change starting > with the 2.1 they also enlarged the fuel tank outlet. > > One thing to keep in mind is that as the engine is running fuel is > recirculating throught eh system, picking up heat from the engine and from > the pumping process eventually raising the temperature of the fuel in the > tank. As the temperature increases so does the vapor pressure making vapor > lock that much easier to occur. If the fuel vaporizes at the suction inlet > of the pump all bets are off. > > My first motorhome (1992 Ford E350 chassis) had this problem with the pump > even installed in the tank. At one point down in Florida I got stuck with > it. After being towed to a dealer the tow truck driver told me that this is > a common problem and in a few hours it will run again. Ford's fix with a > redesigned pump which also required a new mount, gauge sensor, and some > other stuff. Some $900 later plus a rental car etc. All that on a vehicle > with less than 40,000 miles on it. FWIW my 88 Fox has two pumps, a transfer > pump in the tank and the main pressure pump. Common on many VW products. > > Dennis |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.