One thing that we should consider when posting either stories or advice is the consideration for how things can be interpreted especially by those that are less knowledgeable or experienced. It is bad advice to let someone think that it is OK to keep operating the engine when the low coolant warning light is on as long as the gauge says the temperature is still under control. Proper operation of the cooling system requires that the engine assembly is always completely filled and pressurized. The coolant being pressurized prevent localized boiling, (micro vaporization) and keeping everything submerged is obvious. The low coolant light not only indicates a significant loss of coolant but most likely a loss of pressure also. The level sensor is set so that the feed to the water pump should still be sufficient to prevent it from cavitation but how long this is true depends on the size of the leak. At this point the cooling system is compromised. The gauge continuing to show "normal" just indicates the coolant is still flowing enough for the radiator to do its job. If the coolant flow stops the gauge may even drop until whatever coolant left in the engine begins to produce enough steam that the steam travels and gets to the gauge sensor. At this point the pressure cap may not relieve enough volume and failed hoses and manifolds become the blame if not an additional failure point. While the engine is operating with the coolant level dropping the tops of the cylinders and heads go dry and heat up unevenly. Studs get pulled, the gaskets get cooked, and if driven too long and hard bad things happen. The engine at this is suffering a trauma and even if it appears OK after repairs it may never be the same. Dennis |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.