Date: Fri, 14 Dec 2012 11:46:17 -0800
Reply-To: neil n <musomuso@GMAIL.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: neil n <musomuso@GMAIL.COM>
Subject: Re: Starter Motor Sudden Failure: Normal?
In-Reply-To: <50CAEC51.8070608@turbovans.com>
Content-Type: text/plain; charset=ISO-8859-1
Thanks Scott and Tom
Yah, ironically, this van is in "transition" mode; the aux. battery is
in the middle of being installed and my jumpers, spare ignition
switch, starter motor, are all in the other Westy.
"helpers" at the mall are usually much older than me, and/or are well
dressed and well heeled females, neither of which I would consider
asking to push my Westy. This is not a sexist age-ist attitude! Just
based upon respect and logic. :^)
(then again, chances are greater that someone over 50 is sure to know
how to drive a standard transmission!)
I recently installed a "kill switch" to turn off the remote power door
lock system and stereo memory. But even though I've left those items
"on" the last while, battery was still showing 12.8 Volts and easily
took a charge when topped up about a month ago. (due to these sources
of electron drain)
Tom: having a battery switch was something I was considering installing.
Scott: more irony. The recently purchased remote start switch is still
in the package, and very likely buried in my electrical parts
box...... located in the stranded '88 ! Didn't think of it as a
trouble shooting tool. Something to remember!
Neil.
On Fri, Dec 14, 2012 at 1:07 AM, Scott Daniel - Turbovans
<scottdaniel@turbovans.com> wrote:
> if the parking lot is always busy ..
> there will be helpers around to push,
> I sure recommend a 'starter trigger' wire in the engine compartment ..
> ( connected to the solenoid trigger terminal and stashed in the engine
> compartment where you can touch the other end to your hot alt post ...very
> handy for testing purposes, self-rescue, and to connect your Remoter Starter
> switch to for doing compression checks, etc. )
>
> It does sorta sound like a suddenly dead starter to me.
>
> Did you eyeball and wiggle/twist on the battery cable clamps at the battery
> ?
> ( though if they are weak and loose contact it's usually not the symptom you
> are describing ....about the headlights going nearly dim. )
> On 12/14/2012 12:13 AM, neil n wrote:
> .... Voltage at battery and alternator
> stud: 12.8 Battery posts + clamps, and starter 30 connection are
> clean. Solenoid connection is fairly clean. (certainly not corroded)
> Turning key dims headlights nearly completely.
>
> I'm hoping it's the ignition switch but if not......
>
> Can a starter (or solenoid) just suddenly fail? In my experience they
> usually give warning signs; slow and/or intermittent cranking.
--
Neil n
65 kb image Myford Ready For Assembly http://tinyurl.com/64sx4rp
'88 Slate Blue Westy to be named.
'81 VanaJetta 2.0 "Jaco" http://tubaneil.googlepages.com/
Vanagon VAG Gas I4/VR Swap Google Group:
http://groups.google.com/group/vanagons-with-vw-inline-4-cylinder-gas-engines