Grounding is certainly important, and on our vintage ('85) you need to add a wire from the alternator to the starter to avoid low voltage as well, especially since you seem to have a lot of corroded connections: http://www.van-cafe.com/home/van/page_780_449/alternator_cable_upgrade.html
Check the ground strap from the front of the transmission to the body too, both the engine and transmission should be grounded to the chassis.
Hopefully you are on the road to recovery!
Stuart
From: Craig Cowan [mailto:phishman068@gmail.com] Sent: Saturday, February 02, 2013 12:19 PM To: Stuart MacMillan Cc: vanagon. com sending Subject: Re: TERRIBLE GAS MILEAGE/Running Cold?
Well, i've gotten a step closer to solving the running issues, i believe. Yesterday i found the temp gauge will still dive above 60mph, and it was warmer (25*F or so?), but i think the issue is bigger than just a faulty/weird thermostat. I think my 8mpg running is in part coming from terrible grounds. When I first built this bus, for whatever reason I seem to have forgot to deal with the grounds? My chronically slow starting condition suddenly made since, and i dove into the engine bay to find the braided cable snapped off in my hand, and all the ring terminals looked like crap. I cleaned up some of the ring terminals and replaced the ends of a few others. I put a 4 gauge grounding cable from the engine to the body and from the starter motor's lower bolt to the body. My starting is still screwed up, but seems improved. I can't wait to see how this effected fuel economy. I imagine the entire fuel injection system was reading poorly if the grounds weren't sound. Hopefully my messing with wires didn't awaken any new beasts..... We shall see. -Craig |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.