Date: Sat, 5 Oct 2013 13:12:52 -0500
Reply-To: JRodgers <jrodgers113@GMAIL.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: JRodgers <jrodgers113@GMAIL.COM>
Subject: Re: Distributor swap - 2.1L
In-Reply-To: <525055B5.4000700@cox.net>
Content-Type: text/plain; charset=ISO-8859-1; format=flowed
Mark, thanks. Sounds pretty straight forward.
John
On 10/5/2013 1:08 PM, mark drillock wrote:
> Leave the timing clamp tight on the distributor. Remove the 13mm headed
> nut that holds the clamp down to the block. Then pull the distributor up
> and out of the block with the clamp as a unit. That way you won't have
> to adjust the timing.
>
> You will need to remove the distributor cap so you can rotate the shaft
> during reinsertion. The shaft end is keyed and you need to get the key
> lined up and fully seated.
>
> Mark
>
> JRodgers wrote:
>> As mentioned in an earlier post - I think I have a Hall sensor problem.
>>
>> At the moment - given my circumstances - it appears the easiest way to
>> confirm this would be to swap out the distributor for a known good one
>> with a known good Hall Sensor.
>>
>> Distributor with suspect Hall sensor is on an '88 GL. The other
>> distributor known to me to be good is on a '91 Carat that is in a state
>> of refurbishment - not the engine - but the van. Thd engine runs fine -
>> just the van can't be driven.
>>
>> Is there anything I should be particularly mindful off in doing this
>> swap. How about timing issues. Any tricks to going from one engine to
>> the other without upsetting the timing terribly bad - or is re-timing
>> the engine just going to be part of the game?
>>
>> Thanks for any suggestions.
>>
>> John
>>
>
|
Back to: Top of message | Previous page | Main VANAGON page
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives
@ gerry.vanagon.com
The vanagon mailing list archives are copyright (c)
1994-2011, and may not be reproduced without the
express written permission of the list administrators.
Posting messages to this mailing list grants
a license to the mailing list administrators to reproduce
the message in a compilation, either printed or electronic.
All compilations will be not-for-profit, with any excess
proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively
towards the management and operation of the Vanagon mailing
list and vanagon mailing list web site.