Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (May 2014, week 4)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Sun, 25 May 2014 21:41:20 -0700
Reply-To:     Jim Arnott <jrasite@EONI.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Jim Arnott <jrasite@EONI.COM>
Subject:      Re: Rear axle replacement advice
Comments: To: Geneva Saint-Amour <genevasaintamour@HOTMAIL.COM>
In-Reply-To:  <BAY179-W547353174EA8C3F4D8A3C9D43B0@phx.gbl>
Content-Type: text/plain; charset=windows-1252

Broke the axle? Or had a CV joint fail? Either way, you can R&R it. You’ll need nirtile gloves, 4 freezer bags to contain the grease, (you put them over the joint after you take it loose), a 6 mm Allen wrench socket or 6 mm XZN (aka triple square) socket (depending on which fasteners you have) to remove the CV bolts, a 6” socket extension and ratchet and a jackstand to hold the corner of the bus up. There’s really not much to it.

From the vanagonauts site: "clean the dirt, mud, grease. etc. out of the hex or 12-point holes with a pick or piece of wire, before trying to insert the appropriate tool and break torque on the fastener. I always tap the 6- or 12-pt bit 'home' inside the bolt recess before applying force.”

http://www.vanagonauts.com/[42.7]-Constant-Velocity-(CV)-Joints140.htm

The above is the secret to success. If you strip one out, 5” Vise-grips® can save you.

Right knows no boundaries and justice no frontiers. -- Learned Hand

On May 25, 2014, at 8:57 PM, Geneva Saint-Amour <genevasaintamour@HOTMAIL.COM> wrote:

> Today we broke the drivers side, rear axle. We have several questions that we hope someone can assist with. (1985 Westfalia, Bostig with AW high top)1. Can we replace this ourselves (yes, mechanically handy and have general tools)?2. Should we replace both or anything else while we are in there?3. Where should we purchase a new one from?4. Details, tips, secret handshakes?Thanks,Geneva and Mike(Prescott, AZ)


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.