Digging around, I found this...(from a Porsche mechanic ) so likely close. Coil Resistance Check Primary...0.4-0.6 ohms Secondary...5000-7200 ohms Does that seem about right? Pat 89 westy
From: Dennis Haynes <d23haynes57@HOTMAIL.COM> To: vanagon@GERRY.VANAGON.COM Date: 11/19/2015 07:53 AM Subject: Re: crank, wont start Sent by: Vanagon Mailing List <vanagon@gerry.vanagon.com>
Most likely what happens is the insulation breaks down and during the high voltage spike some of that energy shorts out and you get a weak spark. It may not be obvious when checking but keep in mind the other losses between the coil and the spark plug, especially the gap between the distributor rotor and cap pin. A bad coil can even test good with an ohm meter. For diagnostics it is best to short the output to ground. Besides safety the open circuit will cause high voltage stress on the insulation. The output current is really self-limited by the resistance of the output coil. And yes coils can be damaged by being energized continuously.
Dennis
From: Larry Alofs [mailto:lalofs@gmail.com] Sent: Thursday, November 19, 2015 10:31 AM To: Dennis Haynes <d23haynes57@hotmail.com> Cc: vanagonlist a <vanagon@gerry.vanagon.com> Subject: Re: crank, wont start
What do you think can cause coil failure, besides simple deterioration from age and heat? Is it a bad thing to short the HV coil wire to ground while doing a compression test? Would continuous current thru the primary side cause overheating and damage?
When I find old coils lying around in vans that I have bought for parts, I get the feeling that people have changed them attempting to fix other problems.
Larry A.
On Wed, Nov 18, 2015 at 11:34 PM, Dennis Haynes <d23haynes57@hotmail.com < mailto:d23haynes57@hotmail.com> > wrote: Until recently I have not seen the coils fail often. I doubt I have done a dozen and I know of 5 in the past two years. I keep one on the shelf now. They are just getting old. I always give thought though to what may have caused it to fail. Dennis
> |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.