Thanks, Dennis. Now, I'm thinking the trouble might in fact be those connectors in the fuse box as why else after repeated attempts would my removing and replacing some unknown relay on top of the fuse box fix (temporarily) the problem. So that will be my first look. On Wed, Dec 16, 2015 at 8:52 PM, Dennis Haynes <d23haynes57@hotmail.com> wrote: > To begin with the fuel pump and fuel injection relays are mounted in a box > above the ignition coil. There are no relays up front for either unless > something was added. You need to do some real troubleshooting. From the > ignition switch to the ignition coil the path does include going into and > back out of the fuse box. It is fairly common for those pin connectors to > burn up a bit and create an intermittent connection. No fuses are involved > but the box is used to connect the two harnesses. > > Looking at the wiring diagram note tracks 11 and 13. Bridge the wires at > connector A8 to D15 and this will address the connector problem. Pay > attention to the indicator lights while cranking the engine also. It is > common for an ignition switch to fail in a way where the ignition circuit > will turn on and then turn off again as the key is turned to the cranking > position. > > For those that also have starter not cranking issues also not the that the > starter solenoid circuit also has a run through the fuse box. Connectors B8 > to D24. For those adding relays there is also a connection to the brake > warning light system and for westys with the fridge relay. Both use the > solenoid as a ground and replacing the solenoid coil with a low current > draw relay can mess up both circuits and disable the cruise control. > > Dennis > > > > -- 86 Campmobile Six-Seater "Monty" Black dogs are euthanized at a greater rate than other-colored dogs, regardless of temperament. Learn about Black Dog Syndrome at http://www.blackpearldogs.com/ Learn about black dogs in a Vanagon at http://www.pbase.com/mhersh/image/108220533 |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.