Thanks Dan. Pretty sure no water in the gas. Has been in the garage for months.
-Wes
From: Don Hanson [mailto:dhanson928@gmail.com] Sent: Sunday, May 21, 2017 4:47 AM To: Wes Neuenschwander Cc: vanagon@GERRY.VANAGON.COM Subject: Re: Intermittent Power Loss - '91 Westy
check the gas. water? in it?
On May 20, 2017 10:48 AM, "Wes Neuenschwander" <wes.neuenschwander@comcast.net> wrote: While preparing our 'trusty' '91 Westy for a trip to the remote (and supremely lovely) Okanogan region of Eastern Washington, I experienced a sudden loss of power, with the rpm's dropping from 3,000 to around 800, even with the throttle depressed. Still on my local Seattle neighborhood streets, I pulled over and after a minute or so was able to nurse the engine back up to 3,000 rpm, restoring power and driving back home. Took it directly to my regular (and every excellent) local VW shop, Fine Tuning in N. Seattle, without any power loss or other problems. The car repeated the power loss during a test drive, this time losing power completely and engine dying. The owner, Chris, was able to restart the engine after a couple of minutes and got it back to the shop, where they went over the obvious stuff, not finding anything. Next day, they started the vehicle and left it idling for an hour or so, without problems. Subsequent test drives also went without problems.
On Chris' suggestion we disconnected the O2 sensor and I've been driving it, mainly on short, local drives now for several days without incident.
Haven't encountered anything similar in the 26 years we've owned the van (bought it new in '91), though have barely driven it for the last couple of years (like 700 miles over 2 years!) with the van sitting in the garage, idle, for the last several months or so.
In addition to the O2 sensor / sensor wiring possibility, Chris has also suggested it could also be a faulty ECU. The ECU is original, and I know these tend to have solder joint corrosion problems over time. I'm not sure how old the O2 sensor might be, though it's probably not original (but I suspect it's pretty old). Ditto, I guess to a degree, various other sensors, as well as sensor wiring. Ignition components, including spark plug wiring, distributor, etc. have been fairly recently been replaced.
The engine is a GoWesty 2.2L engine, installed nearly 10 years/25,000 miles ago, and aside from the recent loss of power problems, has run beautifully since it was installed.
I've done a lot of searching of the Vanagon List archives for information about similar loss of power problems, so realize the O2 sensor and ECU issues are commonly involved in such situations, but would be most grateful for any/all ideas or suggestions for other things to check. At this point I'm more than willing to invest in a replacement O2 sensor and even (if it seems indicated) a rebuilt ECU. However until something is found that reasonably explains these random power loss events I'm very reluctant to drive the van very far and certainly not into remote areas.
Many thanks (as always)!
-Wes ___________________ Wes Neuenschwander wes.neuenschwander@comcast.net C. 206.498.8787 |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.