Hi Ed, > The solar panel is putting out 17 + volts in the overcast so it is working This may not be a healthy panel. Generally a regular "12V" crystalline panel should put out 20+V open circuit if there's light on it. The gold standard check for your panel and wiring is to bypass the controller, and connect the panel directly to the battery through an ammeter. You can do this where the controller is normally connected. In full sun, no partial shading, and an angle that's not too far off, you should see at least half the rated panel current (Imp or Isc; they will be similar). Panels and wiring exposed to the elements often fail with a high resistance, so it's common to see voltage with no current behind it when there's a problem. > and my aux bat is down to 4 volts will put it on a regular charger today Most charge controllers run off the battery, not the panel, and require some minimum battery voltage to operate (say 8-9+V), so this may be the reason your controller appears dead. Best to get the battery charged a bit and check again before replacing it. You can connect the panel directly to the battery if needed. Monitor the voltage manually. Be aware that if the battery is very far gone and the sun is strong/panel large, the voltage could shoot up immediately, and may damage sensitive electronics. > I must admit I sometimes forgot to turn off the charge controller to the aux bat before starting the engine and having it take over the charging I assumed that > it would not ge good to have both charging the aux bat Generally, there is no problem leaving both charging sources connected. Keep it simple. > I am starting to look for a replacement on Amazon any suggestions > > Now it is only charging the aux bat I would like to have it also charge the main bat Not sure how big your panel is, but from our range, you could try the compact Genasun GV-10, or if you want automatic trickle charging for your start battery, remote displays, etc, the Blue Sky Energy SB2512iX-HV. These are both made-in-the-USA MPPT controllers, with multistage charging, available temperature compensation, USA support, and are Vanagon proven. :) https://genasun.com/all-products/solar-charge-controllers/gv-10-pb-10a-solar-charge-controller/ http://www.blueskyenergyinc.com/products/details/solar-boost-2512i-hv-2512ix-hv Best, Alex |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.