Date: Sun, 17 Apr 94 01:35:27 CDT
Sender: Vanagon Mailing List <vanagon@vanagon.com>
From: Joel Walker <JWALKER@ua1vm.ua.edu>
Subject: index of tech bulletins affecting vanagons
this is what i've found so far. some of these i cannot type in, because they
have pictures/diagrams.
............................................................................
Affected Model Order Affected
Model Years Number Component Subject
------------ ------- -------- ----------- -----------------------------
Vanagon ALL 87-N06 General Vanagon "Dust Buster" air
filter - Heavy Duty Air Filte
Vanagon ALL 10-87-02 Engine Remanufactured Engine
Identification
Vanagon 1983-85 17-87-04 Engine Oil Leak from Rear - Oil pump
gaskets
Vanagon ALL 17-87-05 Engine Oil cooler seal leaks in
waterboxer extreme cold
Water-cooled 1983-85 19-87-02 Engine Coolant leaking and/or noise
Vanagon from rear water pump
Water-cooled 1983-85 19-87-03 Engine Carpet wet by rear seat -
Vanagon Heat Exchanger T-piece leakin
1.9 liter 1982-85 87-N05 Engine Easy Does It - Cross-over
Vanagon Water Pipe
Water-cooled Thru 27-87-04 Electric Alternator Mounting Bolt
Vanagon Model loose/broken
Diesel, Year
Vanagon 1985
Vanagon ALL 42-87-01 Suspension Knocking noise from rear -
Wheels CV Joint
Vanagon ALL 66-87-03 Body Outside Mirrors, Electric
Exterior Mirror Assembly - Removing/
Intalling
Vanagon From 64-86-06 Body Power Operated Window Motor -
3/86 on Exterior Removing/Installing
Vanagon 1983-85 55-87-01 Body Push Button Operation
Exterior Difficult - Rear Lid Latch
Vanagon 1984-85 68-84-01 Body Rear Bench Seat Belts
Wolfsburg Interior
Vanagon 1983-85 70-87-02 Body Front Carpet Seam Gap
Interior
Vanagon 1986-87 87-N04 Fuel Vanagon Surging/Stalling -
System Adjusting Throttle Switches
Vanagon From 66-87-01 Body Outside Mirrors (Electric) -
1986 on Exterior Increasing Mirror Glass
Adjustment Range
Water-Cooled From 87-87-02 Climate Water out of A/C Vents -
Vanagon 1986 on Control A/C on
Vanagon 1987 87-N08 Fuel Basic Digifant Assumptions -
System Digifant Management System
Vanagon 1987 63-87-01 Body Front Bumper/Spoiler -
Wolfsburg Exterior Removing/Installing
Vanagon 1986 87-N02 Climate Don't Blow Your Top -
Control High Pressure Discharge Hose/
Remove Damper
Vanagon From 24-89-04 Fuel Digifant I: Fuel Injection
1986 System System Cleaning and Intake
on Valve Decarbonization
Vanagon ALL 88-N09 Fuel Throttle Switch Adjustment Ti
Vanagon ALL 30-89-01 Manual Clutch Disc - Installing
w/ Manual Trans.
Transmission
Vanagon ALL 34-89-02 Manual Position of Boot on Shift
w/ 091/1 Trans. Rod Bushing
Transmission
Vanagon ALL 34-89-03 Manual Revised Shift Lever Bearing
w/ Manual Trans.
Transmission
Vanagon ALL 40-88-01 Suspension Upper Control Arm Bushings,
Wheels Checking
Vangaon ALL 42-89-01 Suspension Coil Spring, Installation
Syncro Wheels Position
Vanagon From 76-89-01 Body Refrigerator Air Supply
Camper 1980 Interior Modification (Dometic 182
on Models)
Vanagon 1986-89 87-89-01 Climate Evaporator Housing - Change
w/ A/C Control
Vanagon ALL 15-90-T01 Engine Cylinder Head Re-Seal
Water-Boxer (1.9L and 2.1L)
Vanagon ALL 20-90-01 Fuel P.I. 2082 - Accelerator Cable
System Change
Vanagon ALL 24-90-03 Fuel Throttle Body - Replacement
w/ Digijet System
Injection
Vanagon 1983-90 24-90-T01 Fuel Rough Idle, Engine Stalls -
System Tow In
Vanagon From 28-90-01 Ignition Vehicle Does Not Start,
1986 System Ignition Miss
Water-cooled 1983-85 80-87-01 Climate Carpet Wet by Rear Seat -
Vanagon Control Heat Exchanger Bleeder Screw
Broken
Vanagon ALL 87-84-06 Climate A/C Evaporator Blower Motor -
w/ A/C Control Installation of Reinforcement
Plate
Vanagon 1984-85 87-85-01 Climate Factory Installed Air
Control Conditioner - Replacement of
A/C Refrigerant Hose Mounting
Clamps
Vanagon From 87-87-04 Climate Remove Noise Damper from A/C
w/ A/C 1986 Control Refrigerant High Pressure Hose
on
Vanagon ALL 90-86-02 Electrical Non-Interchangeable
System Cigarette Lighter
Vanagon ALL 97-87-05 Electrical Engine Cranks Too Slowly or
Water-Cooled System Won't Crank - Battery Cable
Vanagon ALL 97-87-07 Electrical Engine Stalls and Misses
Water-Cooled System Intermittently / Fuel
Injection Wiring Harness
Vanagon ALL 87-90-01 Climate A/C Evaporator -
Van Camper Control Water Leaking
Waterboxer
Vanagon ALL 90-90-01 Electrical Speedometer Noises (Except
Except System Syncro)
Syncro
Vanagon ALL 90-90-02 Electrical Instrument Indicator Lights
System Malfunction
Vanagon 1986-88 88-N07 Cooling Coolant Loop - Transmission
System Removal
Vanagon 1988 88-N08 Fuel "Terminal Illness" (Idle
System Stabilizer System Changes)
All w/ ALL 20-90-02 Fuel Gasoline Containing Detergent
Fuel System
Injection
All w/ ALL 20-90-T01 Fuel Improved Fuel Additive
Gasoline System ZVW 239 003
Engines
ALL ALL 27-87-03 Engine Cruise Control does not work
Models Years Vacuum loss
..........................end................................................
