spent sunday messing with the reverse light on the blue beast (83 diesel) The ramp phenomenon reported earlier (reverse lights work with back end up, dont work with the car level) isnt repro. this time..... Also, the switch VW sold me isnt working right, if i push the switch in, the lights come on and stay on. I'll take that up with them later .... Well i have to get these thing working to get my (overdue) inspection sticker. Decide to wire a switch to the dash. Check the wiring diagram, 83 diesel. 12V supply comes off fuse #12, switch on trans always hot. Plan is to switch 12V at dash, jump trans switch. i have a flash of inspiration and unscrew the left rear taillight assembly and pull it around the corner so i can see the lights from up front! I pull fuse #12, and the lights still work!! I mutter something not very printable about $80 manuals with bad wiring diagrams .... I finally find the hot wire going to the reverse lights; its on the HOT side of fuse #12, ie its not fused at all .... this is not good. I rewire it through the switch, fused, and now my dash light switch controls the reverse lights = YEAH! BUT .....when i start up i cant get the glow plugs to light, nor the engine to run unless i have the reverse lights switch on!!! The 12V hot wire that feeds the reverse light circuit also feeds the glow plug relay and the stop solenoid (fuel cutoff) circuits - despite what the wiring diagram says. So unless i drive down the road with my reverse lights on i cant run the car, This week i will have to pull a wire from front to back so that the rl have their own, isolated 12V supply. I spent the rest of the afternoon trying to get my license plate lights to work, anyone have any tricks getting these buggers back into place? I had to put some terminal connectors on and they dont let me fit the assembly back into the hole in the body. i think i will hard solder wires on them today at work. all in all, a frustrating day, and i still dont have my damn van back... any condolences will be gratefully accepted, if you read this far!!
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.