> > > My Uncle bought a 76 westy that just had a new top end job. It ran great > > for a few thousand miles and then the valves began to tighten. They > > would retighten a couple of hundred miles after adjustment. The engine > > finally gave up when #3 piston exploded. He is rebuilding the engine now, > > and the shop that checked the heads said they showed signs of over heating. > > Does anyone have/had the same problem, or know what the cause might have > > been? The engine was not neglected oil wise. > > I'd speculate that perhaps a valve broke and the loose piece caused the piston to break up. This has happened to me on my old '64. The fact that the valve clearances were tightening up rapidly may have been an indication that the valve stem was stretching. It can also be caused by valve seat recession <seats too soft> but I think that occurs more slowly. One should probably be suspicious of the buying a vehicle that has "just been rebuilt". If the previous owner has decided to sell _before_ doing the rebuild chances are they will go for cheapest everything and I think we all know that there are a lot of inexpensive, poor quality, unreliable aftermarket parts available for VWs. As to potential causes for overheating: check the cooling system flaps to make sure they open and close properly and make sure that the previous rebuilder didn't leave out the tin directly under the cylinders. Ensure that the engine is tuned to factory specs, especially the igition timing.
Dave
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.