Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (April 1995)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Fri, 21 Apr 95 10:49:34 MDT
Sender:       Vanagon Mailing List <vanagon@vanagon.com>
From:         aburczyk@dres.dnd.ca
Subject:      Re: I will survive

> 
> I posted a little one liner yesterday about the '72 bus 4-sale.
> ***It was sold over the weekend to a relative of a list member.***
> 
> I'm going to replace all of my vacuum lines and and as many fuel
> lines as I can over the weekend.  Just a little Preventive Maint.
> 
> Sorry for the wasted bandwidth folks. Have a nice weekend,
> Jack  '73 Westy
> -----------------------------------------------------------------
>  Jack A. Stafford                 |  Hughes Aircraft Company
>  Engineering Specialist           |  Microelectronics Division
>  Design Systems Department        |  Bldg. 700, MailStop B1260
>  (714) 759-2077                   |  500 Superior Avenue
>  (714) 759-2913 FAX               |  Newport Beach, California
>  stafford@alcor.hac.com           |                 92658-8903
> -----------------------------------------------------------------
> 


Be extremely careful of the stretch of fuel line from the tank to the fuel pump.
The tank has a sump so if you pull the line off it will continue to gush down
on your face out of the gas tank nipple.  The nipple is 5 mm as well which is not a common
fuel line size (Nothing else will do).  I drained the tank via siphon first and then had a large catch
under the van with me to catch the last 1/2 liter or so.  I then replaced the line
since it was 20 years old and put in a ball type shut off valve between the tank
and the fuel pump.  This allows me to shut the flow off completely if I pull the engine
(3 times now- I'm learning) and if I want to drain the tank to play with the 
lines prior to the valve I can put on a long line after the valve and allow it to drain away using the valve to control the flow.
Also I can use the valve to make sure that the engine won't start for someone
unfamiliar with my van.  Unfamiliarity breeds confusion.


What ever you do do not set yourself on fire under the van since the transaxle
has a magnessium case that will light up a city block if it goes.  That would also ruin your day
and the van.


A. Burczyk


'73 bus
Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!

Return to the archives @ gerry.vanagon.com

The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.