Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (May 1995)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Mon, 15 May 95 15:23:15 PDT
Sender:       Vanagon Mailing List <vanagon@vanagon.com>
From:         stevie@tekgen.BV.TEK.COM
Subject:      Re: New life for worn out air flow meter 

I'm the one that complained about poor idle on my '85 van. It's always fun to go down various paths to attempt a fix:) I thought my idle stabilizer had gone out and was in the process of trying to prove it when I discovered the van was runing very rich. Hmmm... this was always a symptom of a dirty resistor substrate in the air flow meter. But I had already cleaned it to no avail. Well I took a closer look and found that a couple spots were worn through. Yikes! These things must cost a zillion bucks so I wondered about alternatives. That's when I noticed that the substrate is attached by three screws. Two on one side and one on the other. Well I took the one screw out of the one side and was then able to pivot the substrate so that the wiper came in contact with non worn substrate.

Well, now I have a smooth runing engine again! I'm hoping I have fixed the problem and have not given opportunity to others that might crop up as a sonsequence of messing around with the substrate. Any opinions? Has anyone else had problems with the substrate wearing through? Are rebuild kits available or do you have to buy new units from VW?

Steve


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.