William Sheel writes: > > I am a new VW van owner (1973) with a slipping clutch. I have a couple > of VW repair books and have been contemplating fixing the clutch myself. > I have a couple of questions that some of you may be able to answer and > make the job easier. > > 1. Just because it is slipping does it need to be replaced? Probably, but you should check the free play in the clutch pedal first to make sure it's not too tight. Basically, the clutch pedal should have about an inch of free play at the top, and should disengage about half way to the floor. > > 2. I am new to VW's and mechanics in general. Is this too much to > attempt on a first try or is it pretty simple if you follow the manual? > I.E. is there potential to do more damage by installing a new one improperly? It's hard to mess up putting in the clutch, but you do have to pull the engine. > 3. How much extra wear am I putting on the engine by drving it as is? > Lots? None? As long as the pedal is adjusted properly, you will not be hurting the engine - assuming you are not over-revving it. If the clutch disc is really worn, you can score the pressure plate and/or flywheel when the pad on the clutch disc wears through. You may be able to hear this when it happens, or you may not. Some people resurface the flywheel and replace the pressure plate when they change the clutch. If you are one of these people (I am not) you might not care if the pressure plate and flywheel get scored. I only fix parts when they break, and so far I have never needed to replace a flywheel or pressure plate in a VeeDub bus. Other cars are a different story, tho. If you drive the bus the way it is, just know that you are risking scoring the pressure plate and/or flywheel. It's also possible that you have an oil leak that is making the clutch slip. In this case, you *cannot* re-use the clutch disc. However, in this case you probably don't have to worry about the clutch wearing through, either. -David ============================================================================ David Schwarze '73 VW Safare Custom Camper (Da Boat) San Diego (Actually La Mesa) '72 VW Westfalia Camper (Da Project) California, USA '73 Capri GT 2800 (Da Beast) e-mail: des@teleport.com '87 Mustang Lx 5.0 (Da Sleeper) http://www.teleport.com/~des '93 Weber WG-50 (Da Piano) ============================================================================
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.