>If you have an early bus and if the heater smells of exhaust fumes, the joint >between the heat exchangers an muffler should be one of the first things to >check.
(Through '71) grind down the inside diameter of the clamps on the header side a bit to compensate for the larger diameter tubes. The fit and ease of installation of the clamps improves. These clamps, and the rest of the exhaust system, should be tightened at each tune-up, they are always loose, especially on the '68-'71 buses where they are hard to reach because of the engine mount. A 10mm deep socket on a 1/4 drive with a 6" extension, along with a 10mm combo wrench, are my favorite tools for this job.
>In about half the cases where a customer complains of exhaust fumes coming >from the heater, the problem is not the exhaust system or heater but failed >engine compartment seals, particularily around the engine compartment hatch. Indeed, now that my bus has accident induced ventilation through the rear hatch, I can detect exhaust fumes. I'm not keen on driving with the heat on when aftermarket air cleaners are in place. The stock single carb air cleaner contains the fuel stand-off very well. Aftermarket paper air cleaners allow fuel stand-off vapors to enter the engine compartment air stream. Eug, '71
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.