Date: Mon, 17 Jun 1996 09:01:26 -0800
Sender: Vanagon Mailing List <vanagon@vanagon.com>
From: Glen Buhlmann <gbuhlman@direct.ca>
Subject: Re: Gas Smell: Flange to Filler Tube
Patrick Flynn wrote:
>
> My 75 Campmobile smells of gas when full and I recently checked the
> flange/seal to the filler tube and have noticed it is cracked and split. This
> connects with four screws to the body of the bus at the filler cap. Has
> any one replaced this. It is like a 3 inch seal of some sort. Will this solve
> my problem or will I find that where the filler tube connects to my gas
> tank more corroded rubber. Will I have to drop the engine? Can I continue
> to drive with 1/2 to 3/4 a tank of gas. I really would not like to see my bus
> burn up. I have recieved some suggestions, I would appreciate many
> more. Hope everyone had a nice weekend.
Well if this is the rubber boot at the top of the filler neck then here is what I had
done recently.
I had a gas smell when cornering with a relatively full tank in my 77. So I replaced
this boot since it was cracked. This reduced the problem but didn't solve it. There
is also a rubber elbow (about 4" long with a slight bend in it) halfway down the filler
tube which was also cracked and leaking. VW says that this is a "very specailized
part" with a "very specific bend" and therefore they want something like $150CDN for it
and it must be ordered from Germany which would take 6 weeks. So I got a half decent
one from a junkyard which is starting to crack but is so far airtight. To replace it
my mechanic cut a hole under the bed (you might be able to get in from the round access
plate in the engine compartment if you were quite nimble and possibly removed some
equipment -- but I don't know how your 75 is set up so I'll lelave that to you) and
then riveted/siliconed in back and covered it with duct tape (you know the stuff that
holds the universe together).
Well, that's my story. Don't know how relevent it is to you and I guess you probably
won't know either until you replace your boot and go for a drive with a full tank.
Good luck.
--
+---------------------------------------------------------------------------+
| Glen Buhlmann | "Saw it on the tube. Bought it on the phone. |
| GB Computer Consulting | Now I'm home alone with a piece of crap." |
| Vancouver, BC | --Neil Young |
| '77 VW Westfalia | |
+---------------------------------------------------------------------------+