Date: Mon, 1 Jul 1996 22:12:15 +1000 (EST)
Sender: Vanagon Mailing List <vanagon@vanagon.com>
From: Ian Hallett <halleti@agric.nsw.gov.au>
Subject: RE: Kadrons
On Thu, 27 Jun 1996, John Sirutis wrote, amongst other things:
> 2. The carbs are the same as described in the literature I picked up from
> Autovice. I couldn't find the crossover tubing because it comes off the
> inlet manifolds
John,
I've got Kadrons and my balance tube is not in front of the fan housing.
I installed them myself didn't know that the manifolds are reversible.
You have a choice whether or not you see the balance tube when you look at the
engine. Cosmetically, in front of the housing looks OK but the tube is
harder to get at. I may change mine when I pull the engine later
this year.
> 3. I tuned the pair, before discovering the crossover, and the engine runs
> very smoothly and with good power. It will idle down to 500 to 600 RPM,
> which is a bit low for starting, considering there is no choke or throttle
> adjustment, other than the pedal, for cold operation.
Mine won't idle when its cold. I'm lucky I have a 6 mile trip to town
before I strike traffic and have to worry about idle speed. I've thought
about some sort of idle regulator like I had on a Japanese diesel van.
The idle could be adjusted with a knob on the dash which screwed up a
wire attached to the throttle linkage. Probably never happen but it's a
thought.
> 4. I have two theories about the reason that it died on the first trip after
> the tuning. Either I have a fuel flow problem - clogging or fuel pump - or
> the carb is icing - see below.
I also have the iced carb problem. Hasn't got too cold here yet, only
down to 5 or 6 degrees C so far. My cold carbs won't settle back to idle,
they like to race the engine 'cos the linkages seem to stick. It's sort
of the opposite problem to the slow idle. Again it's not a problem 'cos I
don't have much traffic to worry about.
I heard a story about a fellow who live west of here where the mornings
are much frostier. He worked out some way to run warm air from near his
exhaust pipes, using standard VW ducting, back to the top of his Kadron
air filters. Only does it in the winter then reverts back to the standard
set up for the summer.
If you like I'll may be able to get details.
Regards
Ian Hallett
Orange NSW Australia 2800
email: halleti@agric.nsw.gov.au
'72 bus with 1776 upright & twin Kadrons