At 02:39 PM 4/7/97 -0500, Jeff Diebolt wrote: >>My experience with not reving up under load, was a clogged fuel filter, >>I did not notice any air bubbles in the line at the time. It would seem >>that an air leak could cause similar trouble. Did you check at the >>fuel filter, possibly the small brass screw that is loosened when you >>drain water out the bottom of the fuel filter? or the water drain? >> >My guess is that you are probably having a slightly hard time starting in >the morning. The bubbles in the line do indicate air getting in. The >symptom of only seeing them when the engine is shut off tells me that the >shaft seal on the pump is leaking. It's an easy repair, if you have the >tools to re time it, and if you can find a seal. There is a diesel pump >rebuilding shop a couple hundred mile from me. I just call them up and tell >them the type of pump I'm working on and they UPS the seal to me. Used to >cost about five bucks plus shipping. You have to be real careful removing >the old seal. The shaft is hard and a little bit forgiving of being >scratched but you don't want to take any chances. HTH Well, at this point I have replaced the filter and the fuel line. The fuel line seemed to help a little, but I am still not there yet, What seal are we talking about? Are you talking about the seal on the shaft that is between the injection lines? Can this be done without removing the pump (as I do not have the tool for retiming the pump)? The clutch on the '79 has started to slip (bad) so I need to get this van running (I don't want to have two of them taken apart at any one time, the neighbors (and my wife) will get very irate) Thank you for your help.
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.