I just finished replacing the front wheel bearings on my 93 Eurovan. It has about 80,000 miles on it. Symptoms: Chuging noise/vibration from front at 20 to 50 mph. Not bad but getting worse with time. Slight tendency to make the noise during slight turns (either way) I am the second owner and some work had been done before I bought it (Left outer CV boot, both rack boots, waterpump & timing belt). As you may know EV parts are very hard to get from other then dealers. I called my local parts store (Axel's in Danbury, CT 203-797-0490) and he found a supply. Instead on the $110 from the dealer I paid about 80. I may have gotten them cheaper but Axel is local and I can hammer on him in person if the parts are bad. First, to do anything to the EV front end a holding tool must be made/bought/stolen to stop the upper control arm from swinging down too far. With this tool in place the procedure is very much like on a Syncro. Disconnect upper/lower ball joint, tie rod, brake caliper. Then its just like a Golf/jetta/syncro for removing the bearing from the housing. You can do this with a special tool on the car but I have access to a press and did it off the car. Took about 2 hrs per side. With the new bearings the noise is gone. Donald Gibbons 93 EV MV 87 Syncro (gone) 82 Vanagon Diesel (converted to gas and sold) 73 Super
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.