BatSubject: re starting woes - whir whir 5/22/97 6:33 PM > >Gcarlen@aol.com wrote: > >> Howdy Volks, > It just goes > >> 'whir,whir' as if it had a dead battery (not the case) or was suffering > from > >> vapor lock. Anyone have any ideas? etc. etc. **************************** I've had experience with two battery failure type problems that everyone seems to miss. They get all wrapped up in trying to find some exotic failure mode. So here's two easy to miss failure modes to check. 1. Check the battery connections. Physically pull on them, then take them off and clean them. It doesn't take much corrosion between the posts and the terminal (and it doesn't always show) or it doesn't take much of a loose connection at 400 amps to build a bit of heat, and thru the IR drop, drop the voltage to where the starter won't work. The same holds true for connections to the starter, and connections to ground. (Solenoid may still work at the lower voltage) 2. How old is the battery. they do die, sometimes they die with only one cell going bad. When that happens, you think you have 12 volts, open circuit, but the thing won't have enough kick to spin the starter motor. The minute you try to pull lots of current, the voltage drops to 10 or so, (12 minus one cell) and only the solenoid kicks in. 3. Ok, so I lied. Here's a 3rd item to consider. It's been my experience that anytime something doesn't work, I look at the last thing I changed or did. So, did you just change the starter, did you recently put in a new battery, etc. etc. 4. sorry, thought of #4. My wifes 86 Scirroco would not always start. The connection to the solenoid was tight. What was loose was the connection of the solenoid bolt to inside the solenoid! Tightened up the inside connection by carefully turning the nut on the solenoid connection bolt without turning the bolt itself and all was well. (Now if only VW hadn't hidden the darn starter behind the engine above the axel.) '89 Syncro Ch
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.