Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (May 1997)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Tue, 27 May 97 03:55:43 UT
Sender:       Vanagon Mailing List <vanagon@vanagon.com>
From:         "Dennis Haynes" <dhaynes57@msn.com>
Subject:      RE: Oil on the rear window!!!

The cam is lubricated properly from splash. There are no engines that submerge a camshaft intentionally. Too much windage causes heat build up and foaming. Race engines run dry sump systems and actually keep the pan near empty. Almost all engines have the dipsticks calibrated so that the full mark is actually an overfull condition. This is to accommodate normal losses and inattentive owners. Installing an oil temp and pressure gauge will show the harmful effects of overfilling these engines. Not only do oil temps rise, but watch the falling pressure as the oil gets aerated. You still need to find the leak though. Check the breather mounting to the engine block and the hose to the air inlet.

Dennis

-----Original Message----- >From: vanagon@lenti.med.umn.edu On Behalf Of kenneth d lewis Sent: Friday, May 23, 1997 3:55 PM To: Multiple recipients of list Subject: Re: Oil on the rear window!!!

Curt: At the full mark the cam shaft is submerged in oil, the only source of lubrication for the lobe-to-tappet surfaces. The shaft is ABOVE (out of) the oil at the low mark. Good Luck Ken Lewis

On Fri, 23 May 1997 06:10:17 -0500 JCSYNCRO@aol.com writes: >My '87 Syncro allows oil to leak out and show up on the rear window IF >I fill >it to the full mark on the dip stick. > >At about 1/2 quart down from "full", it no longer leaks. > >Is there a common fix for this, or does everyone run 1/2 quart down? > >Curt Long >Maple Valley, WA (No longer in Thailand) >'87 Syncro Westy >Many other toys >


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.