Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (July 1997)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Fri, 18 Jul 1997 14:57:47 -0400
Sender:       Vanagon Mailing List <vanagon@vanagon.com>
From:         Dan Moy <danmoy@HOME.CYNET.NET>
Subject:      Re: Oil plug stripped, fix needed

Eric, I had the same problem with my 91' when I bought it. The dealer put in a heli-coil with a a drain plug that was oversized. They also used a plastic gasket instead of the alum. one. Needless to say it always leaked because the scarred the sealing surface.

I installed the stock plug and use a 14mm copper crush gasket (same as the beetle oil drain plug gasket) This stopped the leak completely!

Before I changed the oil (for the first time) I talked to a machinist. He said that he could put in a helicoil with out removing the engine, he uses a grease on the tap so as to collect most the metal shavings. Then run some oil throught the engine to remove any strays. Be careful with the sealing suface.

Hope this helps

Dan

On Fri, 18 Jul 1997, Peg Piwonka wrote:

> I didn't do it!!! > > Imagin my surprise when I went under my "new" 84 Westfalia to change > the oil and found a one inch bolt sticking out of the oil plug area. a wing > nut device ther was holding a rubber stopper in place. This thing holds the > life blood of the engine in. I wiggled it and it fel off in my hand! My > oil pan was already there but what if this had happened on the road!!! > I replaced the rubber stopper and it seems to be holding. I ordered > a new bolt from the dealer but I suspect that the inner threads may be > stripped. I'll try a new bolt but then what? I have a good shadetree > mechanic near buy but what is the best fix for this? Help. > > Eric >


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.