In a message dated 97-09-11 08:22:05 EDT, Soineydg@MAIL.MILWAUKEE.K12.WI.US writes: << My idle stabilizer seems to have a hyperactive streak lately. The idle is around 2000 rpm, somewhat intermittently. When I disconnect the thing, it idles just fine at 900 rpm. Any suggestions? >> Could be your idle stabilization control unit. I had this to say about this a while back: ------------------------------------------------------------------------------ --------- Vanagonauts, Recently I related the story of my 87 Syncro suddenly developing a +4,400 RPM idle. I traced this to the Idle Control Module located forward of the right/rear taillight. The dealer said list was $208. I called several wreckers and was quoted from $80 to $20 for this item. I bought the $20 one and it arrived yesterday. Meanwhile I was pursuing repairing the bad module. Inside the module I discovered two components that were suspect. The first one, a voltage stabilizer transistor was definitely fried. I found (from my 88 Vanagon module) a company logo: SGS in tall narrow letters pushed up against eachother & other numbers were BD 438 and 9 741. I found that an ECG or NTE 185 was a replacement component for it. The other component was a rectifier diode that had some signs of being overheated but was not overtly fried as the other component had been. The diode had the numbers GP15G-7001 and GI 8641. I thingk the GI is for General Instruments. Well, found that it could be replaced with an NTE 125 or ECG 125. Yesterday, I installed the two new components and the bottom line is that after poping the module back in, my van idles normally again! :) Cost? NTE185: $2.25 NTE125: $.88 Total: $3.13 + tax Compared to dealer list, I saved about $205. - that's 98.5% less!! :) :) So now I've gone from needing a new module to having a spare for future use.:) Jim Davis |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.