The decrease in oil temperature is real. The temperature sending unit is in the drain plug and is constantly submerged in oil. Other evidence of cooler oil is an increase in oil pressure of about 8 psi at idle (to 10 psi) and about 15 psi highway speeds (3500 rpm, to 45 psi). Recently someone posted a letter about adjusting the oil level to reduce the oil temperature in an air cooled engine while they were making a trip. I couldn't find the letter but I believe it was this year. Maybe someone else with an oil temperature and an oil pressure gauge would like to run a little experiment. All you need to do is to drain your oil, replace your filter, and refill with 4 quarts of oil. Drive on the interstate for 20 miles at 70 mph or until the oil temperature stabilizes. Record the oil temperature and oil pressure at 4000 rpm and at idle. Then stop and add a fifth quart of oil and make the return trip at 70 mph and note the oil temperature and pressure. I bet you will then be looking for someway to remove that last quart of oil because of the dramatic differences. I suggest you just drain the oil out and then add about 3.8 quarts of new oil. Check your dipstick and adjust the level to ~1/4 the way up the "Operating Range". Your engine will then be nice and clean inside and your oil level will be correct. You can then post a really interesting letter to the list. I plan to do this when it gets warmer and I do my next oil change. Someone else could run a parallel experiment to compare results. Ed McLean '86 Westi |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.