After many months of trying to find someone who understood what I wanted on the 82 Westy (forget traditional VW mechanics) and was willing to do the work, I finally found an RV place outside the city (Toronto) and gave him the job. Here's the details, for others who, like myself, have to rely on (and pay) others to do the work. All prices in Cdn$. PARTS - Optima 750U deep cycle battery-$200, ½ amp trickle charger-$40, Headlight Alarm-$14, 12V Propane Detector-$35, extra 12V outlet-$12, 12V meter+switch-$54, interior light and velcro kit-$24, isolator-$15, miscellaneous wiring, fuses, receptacles & covers, etc.-$26 = $420 LABOUR - Install all of above, with all accessories and interior lights (except small light over driver's door), tape deck/radio, propane detector, etc. now wired to draw only from new house battery, both batteries charge while engine is running, trickle charger wired in to 110 volt circuit, change single 110 volt outlet (under sink) to double, (charger plugs in there with fridge), extra 12V outlet mounted near back table, new light mounted on ceiling of pop top, removable with velcro (now occupants up there can read at night) Total Charge - 8.5 hours @$62 = $527 TAXES - various levels take total of 15% = $142 Add some gas to get there and back a couple of times with 2 vehicles, and we're just over $1100! If anyone else in this area is interested, the labour hours required to do the job again would probably come down, now that I've paid for his learning curve! (first time he's worked on VW's - they are used to large motorhomes). Disappointments: - The voltmeter has a switch to read either "house" or "starting" battery, but unfortunately he mounted it on the trough above the sink, so I can't see/check battery condition while driving - Optima top battery posts are a little higher than I thought, so the driver's seat won't swivel anymore! - He couldn't find a 110V circuit breaker to replace the original VW one that often pops (and gets stuck) when plugging in a small heater. I'm not crazy about spending over $100 for a VW original - anyone have any ideas for a replacement? Happiness: - I'm all set for more self sufficient, well lit camping, and can run the tape deck and other accessories as long as I want, without drawing down the starting battery or getting stranded. From other posts, this Optima should serve me well. Many thanks to all those who responded to earlier questions when planning the job. |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.