Hey all, Let me lay out my situation: '81 Vanagon, 2.0L air-cooled, with low compression in #1. Suspect dropped valve seat. I have a spare 2.0L engine that I got when I bought my van. The engine is from a parts Vanagon. Unknown history on the engine, tho I am waiting for a response from the PO on that subject. I took the spare engine apart over the past few days and found that the head I need (right side, 1&2 head) looks pretty darn good. There was a bunch of carbon in the combustion chambers and the spark plugs were fouled with oil. Probably bad rings. Note that most surfaces of this engine were covered in oily grit. It must have been leaking pretty well. After a thorough cleaning things are looking fine. All valve seats appear to be in good order, none of the valve stems stick out higher than any others. Steve Dolan has also examined this head and concurs with me that it is probably usable. My plan is to pull my engine, strip it down to the heads, and exchange the head from the spare engine for the bad head on my engine. While there I plan to replace lots of gaskets and oil seals, but that's secondary. My question to you is: if I go this route, what do I need to do to prep this head for installation on my engine? The head appears to be stock, and I don't see any obvious signs of rebuilding (i.e. no rebuilder's stamp, etc). I assume I will need to check/set deck height all the way 'round. What else do I need to do to make sure this works out? I'd like any advice from those that have been there, done that. Advice on what I need to do to make it work, advice on why I should or should not do this (as opposed to getting rebuilt heads from AVP or Mark Stephens), etc. BTW, disassembling this spare engine, I found that the top of the oil cooler was pretty much 95% blocked off by blobs of oily grit. If your engine appears to be blowing a lot of oil, you may want to clean it up to avoid this. It's clear that the oil cooler on this engine wasn't doing much to cool the oil. Thanks in advance Sean Bartnik Fairfax, Virginia '81 Vanagon L Westfalia |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.