Sounds exactly like the problem I had with my 84 vanagon and my father-in-law's 85. It's being 'flooded' by a malfunctioning coolant temp sensor near the water pump. Here's a trick to start it. In the engine compartment, open the black box over the ignition coil on the left side. Unplug the relays and start it. It will start on just the residual pressure in the fuel system. Immediately plug the relays back in to turn the fuel pump back on.( Works better with two people or how fast can you run around back?) I confirmed the problem with the sensor sending a 'cold' signal to the computer even when warm by a trick from my mechanic. Go to Radio Shack etc. and buy a half watt 100 ohm resistor.
When this happens again (mine was very intermittant and frustrating) unplug the lead to the sensor . It's one of those special ones with the spring clip retainer in the thermostat housing out of the water pump. Push the resistor in the harness and hold in with a bit of tape. This will give a 'warm' signal to the computer and if it starts and runs ok, then buy a new sensor. It's a Bosch part I got from my independent shop for about $35. (It's on page 19.8 in my Bentley manual) I drove home from Eastern WA to SoCal with the resistor in this way. Hope this is of help. Jess Lopatynski 87 GL 85 GTI |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.