Considering the use of the vehicle is important. For daily use I would stay close to the stock configuration for torque's sake. That includes the heavier flywheel which will keep the driveability good. If the law allows it in your state, a free flowing exhaust manifold and muffler can add a bit of horsepower without compromising the low end performance. >1. If the flywheel is lightened, will that give improved response to >throttle?
Yes, but without any other mods it will be most noticeable only in neutral, or after you have begun to roll in first gear and reach your torque / hp peak. Then rapidly flatten out as the engine is not making any more power or rpm. After the shift to second there may be a bit of a difference, but negligible as the greatest resistance to acceleration after the initial roll out is the increasing wind resistance. >2. What about the down sides, such as increased vibration, easier to >stall while lugging, etc...... Don't lug that engine. You are right about the increased likelyhood of stalling, as the stored energy in the flywheel is going to be reduced. This can be compensated for by increased revs and more clutch slipping, but it'll be harder to drive and the clutch may not last as long. >3. If not this, then how to get an easier revving motor? Get the Audi >5 cyl? How much work are you willing to do to the engine? How much money are you willing to spend? What are you gonna be using it for? I'm sure that given answers to these questions there are many group contributors who can give specific advice! Respectfully, Steve |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.