I have read many suggestions regarding my starter question post a while back. Here is a little history that might help. My 87 auto GL originally started fine all the time until the winter came. When the nights started to fall below about 20 degrees at night the van which was not garaged would not turn over in the morning. The lights would dim when the key was turned and I'd hear the apprpriate fuel pumps turning, but no starter engagement sound. After warming up, it eventually would turn over. This could either be accomplished in one of two ways. Either I would try and start it at 5 minute intervals and the resistance heat of the tries would warm it enough to start it or, I would wait until the sun shone into my van's back window and remove the engine lid and let the greenhose effect work for me. Either one would work. But it needless to say, It wouldnt have made a good volunteer firefighter transport vehicle.Planning ahead before use was required. I explained this to my friend who is quite a competent Saab mechanic and he suggested we pull the starter and check it for moisture. Sure enough, after getting it out and apart we discovered rusty moisture all over that plunger unit. We actually cleaned it out and replaced the pitted plunger with one from a starter that I had from an old 79 bus. It worked right off the bat, however, I soon found out that if the starter was used many times (like 3 or 4 starts in an hour) it would need an hour or so to rest before it would start again. This would no longer happen first thing in the morning no matter how cold it was. However now it was doing it while hot. I tried a slight tap with a small hammer on the solinoid while turning the key and that worked onhe starter? The solenoid only? This elusive tip bushing that I've heard mentioned? or... does some fellow listee have an old starter laying around the workshop with busted teeth or something that I can swipe the solenoid side for parts from? Any help appreciated. Keith 87 Wolfie GL |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.