Recently someone posted that they had their coolant lines (engine to rad) replaced with stainless steel ones. It made me think about corrosion and electrochemistry (arggh!), and while motives are not to alarm or criticize other people's solutions I thought I'd post the following points. While the various stainless steel alloys are rated quite passive on the Galvanic Series scale, lying between Silver and Nickel alloys (Platinum at the top - most noble - cathode, Magnesium at the bottom - most active - anodic), it is only because they have a protective oxide layer. When this layer is removed, Stainless becomes more active and falls between Lead and Cast Iron on the scale. The inside of our van's cooling system is anoxic, so presumably any stainless in that environment would corrode at a rate not much better than Cast Iron. I'm sure boat owners on the list are aware of the strange behavior of Stainless steel, seeing rust on sections of the same bit of steel, the rusty areas only differing from the rest in that they are oxygen deprived (by dirt, grease etc.) It is also known that stainless steel alloys are far from perfect in below waterline use. I won't go into the problems of dissimilar metals, except to say that a stainless bolt in an aluminum plate will last a heck of a lot longer than an aluminum bolt in a stainless plate (all in an aqueous environment).
Back to the stainless coolant pipes. While I don't think they are a great advantage in preventing internal corrosion resistance, they probably do resist corrosion from the outside in. Alistair |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.